guoelephant  Single blister Instant Super Glue

Super glue is a single-component cyanoacrylate monomer in the liquid state, capable of extremely rapid polymerization between adherent surfaces, result-ing in extremely strong and structural bonds at room temperature.

This instant adhesive will, with only normal surface preparation, bond all materi-als commonly used in the engineering industry, except polyethylene. Polypropylene, teflon, and very porous surfaces, which require special treatment.

To open tube:

1. Unscrew entire nozzle & cap unit.

2. Reverse cap and place pointed end on top of tube. Point tube away from face, Press to puncture.Do not squeeze tube while puncturing. After puncture is made, replace nozzle & cap.

3. Unscrew outer cap only and apply sparingly. Clean tip after each use.

Application:

Be sure both surfaces are clean and dry. Apply with extreme care. Never spread with fingers. Apply one drop for each 3 cm area. Apply to only one of the surface, Quickly place two surfaces together with slight finger pressure.

Bond is completed in seconds, or depending on material in about one minute, leave for 24 hours for strongest bond.

Clean away all excess adhesive from container with tis-sue paper. Keep out of reach of children, in cool dry place.

Warning: Keep out of reach of children:

Adhesive will stick to skin very quickly, when using, be sure it dose not come into contact with fingers, do not try to pull it off. Soak fingers in warm warter and work off Nail polish remover may also be used. If adhesive get in eye, wash eye with quantities of plain water, do not try to remove by rubbing or applying solvents, in case of pain or discomfort, consult a doctor.

Bond for home uses:

For mending dishes and household articles, tables, chairs, bureaus and other articles of furniture, fishing tackle and other sports equipment, or for use on metal, leather or paper.

 

guoelephant superglue Technical Data sheet

Directions for use:

1.Ensure surface are close fitting,clean,dry and free from grease or dust,

2.Sightly dampen porous surfaces such as china or wood

3,Pointing the bottles away from your body, unscrew the cap and nozzle assembly, then pierce the membrane with the end of the cap. Screw the cap and nozzle tightly back onto the tube. Unscrew the cap and the glue is ready for use.

4.Use one drop of super glue per square inch and apply to one surface

5, Press the surfaces to be bonded together firmly and hold until fully bonded.

6, Avoid spillage as super glue is difficult to remove,

7, Always replace the cap immediately after use, return the tube to the blister pack and retain this for future reference,

Heath and Safety

   Iritating to eyes, respiratory system and skin.

Do not breathe fumes/vapour. Avoid contact with skin and eyes. In case of contact with eyes,rinse immediately with plenty of water and seek medical advice. Wear suitable gloves. Use only in well-ventilated area.    if skin bonding occurs, peel apart in warm soapy water. Store bottles upright in a cool dry place, Dispose of used packs safely.

Warning: Keep out of reach of children and pets,

DANGER, Cyanoacrylate bonds skin and eyes in seconds

Please note: not suitable for bonding glassware, polypropylene or polythene or rayon.

 

1.Established in 1996, about 18 years of history;
2.Owns 2 main factories, one in jiangxi making cyanoacrylate , one in Dongguan making super glue;
3. main brands: Guoelephant
4.Certificates of SGS, TUV, ASTM, REACH, ISO9001 etc
5.Gold member of more than 5 B2B websites: Alibaba, Alibaba Japan,Alibaba China, Made-in-China,etc
6.Production capability more than 6 million pcs/ month;
7.Monthly export more than 50 containers;
8.Exported to more than 50 countries and regions;
9.More than 90 big distributors in Chinese market;
10.With more than 10 sole agents in the world

    Established in 1996, we are specialized manufacturer with years of experience in production, research and development of adhesive. Now our working facilities cover an area of 12,000 square meters. We have over 100 fixed staff members, 35% of which are high or intermediate technicians.
Our leading products include super glue series packed in aluminum tubes, 502 series packed in plastic bottles, 101 series, modified two-component AB series adhesives (acrylate type, epoxy type), contact cement, etc. Among them, the super glue series packed in aluminum tubes reached the international advanced level and the products sell well around the world.
    With our factory responsible for material of glue, packing and export, our products have won reputation in both domestic and overseas markets due to high quality and competitive price. Our annual sales capacity has reached around USD3,000,000 with export percentage of 80%.
Holding the guideline of "Seeking existence through development", we devote ourselves to the unceasing exploration of new products while strengthening the quality of our original products and sets up special quality inspection agencies responsible for the supervision of products' quality. Under the joint effort of our whole staff, our 502 super glue series with the trademark of "GUOELEPHANT" have been well received by numerous customers in China.
    Following the principle of "Quality first; Credit supreme", we are willing to cooperate with clients from all over the world in order to built a more prosperous future together. Please feel free to contact us for details if you are interested in any of our series.

1Q:How do I use guoelephant Super Glue?
A:guoelephant Super Glue is easy to use. It dries in 15-30 seconds and no clamps are needed. Simply clean the surfaces of your project to rid of dirt, dust and grease. Apply a small amount of guoelephant Super Glue (more isn't always the better: use 1 drop per square inch). Then put your pieces together and hold for 15-30 seconds.
You can handle your project lightly after 1-5 minutes. 24 hours required for complete cure.

2.Q:How is guoelephant Super Glue different from guoelephant Glue?
  A:guoelephant Super Glue is a cyanoacrylate adhesive. guoelephant Glue is a polyurethane adhesive.
guoelephant Super Glue does not require extended clamping or moisture to activate. It does not foam during set up. In addition, guoelephant Super Glue is recommended primarily for indoor applications only.
guoelephant Super Glue is ideal for smaller repairs that require an instant bond and projects where clamping is not needed.

3Q:Can I use guoelephant Super Glue on paper?
A:Yes, it will work on paper. Only apply a small amount. It is not acid free, therefore, not recommended for scrapbooking.

4Q:Is guoelephant Super Glue heat and water resistant?
A:guoelephant Super Glue works well up to temperatures as high as 200-220?F. However, too much exposure to extreme heat will cause the strength of the bond to be compromised. Likewise, too much exposure to water, especially warm water, can compromise the strength of the bond.

5Q:Can guoelephant Super Glue withstand extreme cold temperatures?
A:guoelephant Super Glue can typically be exposed to temperatures ranging from -65?F to 200?F without breaking down.
However, there can be variation to this range due to the way different substrates expand and contract in extreme temperatures.

6Q:How do I remove from my skin or my project?
A:To remove guoelephant Super Glue from your skin, soak the bonded area in warm soapy water or acetone (finger nail polish remover works well). The key is to be patient and NEVER pull the area apart.
Gently wiggle the area to allow the soapy water or acetone to penetrate the bond. After soaking, the adhesive should come off easily. Keep in mind acetone can strip your skin of oils, so apply moisturizer after removal.
To remove guoelephant Super Glue from the surface of your project, soak bonded area with warm soapy water or acetone. Keep in mind, acetone can mar the surface material or discolor fabric.

7Q:How much guoelephant Super Glue is in the bottle and why is it half full?
  A:Each bottle of guoelephant Super Glue contains 15 grams of adhesive, though the bottle is only half full.
For high performance and usability the adhesive needs to be protected from air. One way keep the air out of the adhesive is by packaging in thick plastic bottles. If the bottle was completely full at 15g, and still the optimal thickness, it would be too hard to squeeze.

8Q:How can I prolong the useful shelf life?
Moisture that gets into the bottle can cause the adhesive to set up and harden. The best practice is to immediately replace the cap and store in a cool, dry location.
There is a metal pin in the cap of guoelephant Super Glue that helps create a tight seal as well as keep the tip clear of dried adhesive.
We do not recommend storing your guoelephant Super Glue in the refrigerator. Because super glue can release gas, it should not be stored near food.

9Q:What makes guoelephant Super Glue different from ordinary super glue?
A:guoelephant Super Glue has tiny rubber particles that help secure your projects with a less brittle bond. This helps your project resist bumps, bangs and drops. We call it Impact-Tough?.

10Q:What if I swallow guoelephant Super Glue?
Do not induce vomitting. Saliva will cause guoelephant Super Glue to polymerize, or harden, in mouth which means the adhesive usually doesn't make it into the throat or stomach.
If lips are bonded together, use warm water to gently separate. The enzymes in saliva will actually help to break the bond, so patience is the key.
Do not use acetone or solvents on or near your mouth. Do not attempt to pull the area apart as this can tear the skin. Seek medical attention.
guoelephant Super Glue should be left out of reach of children and animals.
For other first aid information, guoelephant Super Glue First Aid

11Q:What do I do if I consume guoelephant Super Glue?
Do not induce vomitting.
Saliva will cause guoelephant Super Glue to polymerize, or harden, in mouth which means the adhesive usually doesn't make it into the throat or stomach.
If lips are bonded together, use warm water to gently separate. The enzymes in saliva will actually help to break the bond, so patience is the key. Do not use acetone or solvents on or near your mouth. Do not attempt to pull the area apart as this can tear the skin. Seek medical attention.
guoelephant Super Glue should be left out of reach of children and animals.

12Q:Are guoelephant Super Glue vapors harmful?
   A:guoelephant Super Glue should be used in a well ventilated area. Inhalation may cause irritation to the nose, throat and repiratory tract. In the case of irritation, remove to fresh air.

13Q:Can I apply guoelephant Super Glue to a minor cut or to repair a broken fingernail?
   A:guoelephant Super Glue should not be used for intentional contact with the skin.

 

  3 gram/tube,1,2,3,4,5,6 tubes /blister card,288 card/carton  

Dongguan Guoxiang Adhesive Products Co ., LTD

CONTACT: NIKE CHOU(CEO)
Telephone: 86+769-81888683
Mobile Phone:86+13620092378
Fax: 86+769-81888781
Address: No.17 Rongxin Road ,Shangsha Third Industrial zone,Changan Dongguan,Guangdong,China
Zip: 523850
Country/Region: China (Mainland)
Province/State: Guangdong
City: Dongguan
SKYPE:z81888682
You can contact us by Email,MSN, Yahoo, Skype,Trademanager,QQ,Telephone or Mobile Phone